Abstract
This article aims to discuss the influence of compressor inlet guide vane (IGV) position on gas turbine switching control system gain tuning problem. The distinction between IGV and normally reckoned working conditions is differentiated, and an improved double-layer linear parameter varying (LPV) model is proposed to estimate the protected parameters under various IGV positions. Controller gain tuning is conducted with single and multi-objective intellectual optimization algorithms. Simulation results reveal that normally used multi-objective optimization procedure is unnecessary and time-consuming. While with the comprehensive indicator introduced in this paper, the calculation burden can be greatly eased. This improvement is especially advantageous when tuning work is carried out under multiple IGV positions.
Issue Section:
Research Papers
References
1.
Zhang
,
Z.
,
Zang
,
S.
, and
Ge
,
B.
, 2019
, “
Study on Multi-Loop Control Strategy of Three-Shaft Gas Turbine for Electricity Generation
,” Aircr. Eng. Aerosp. Technol.
,
91
(7
), pp. 1002
–1010
.10.1108/AEAT-05-2018-01492.
Garg
,
S.
, 2008
, Fundamentals of Jet Engine Control
,
NASA
, Glenn Research Center, Controls and Dynamics Branch, Cleveland, OH, accessed Oct. 14, 2021, http://homepages.wmich.edu/~liou/wp_AE4662008Fundamentals%20of%20Engine%20Control.pdf3.
Chen
,
C.
,
Dimirovski
,
G. M.
, and
Zhao
,
J.
, 2012
, “
Safety Protection Control for the Aeroengines Via Switching Strategy
,” ASME
Paper No. ESDA2012-82340.10.1115/ESDA2012-823404.
Yu
,
D. R.
,
Liu
,
X. F.
,
Bao
,
W.
, and
Xu
,
Z. Q.
, 2009
, “
Multiobjective Robust Regulating and Protecting Control for Aeroengines
,” ASME J. Eng. Gas Turbines Power
,
131
(6
), p. 061601
.10.1115/1.29039055.
Yu
,
B.
,
Ke
,
H.
,
Shu
,
W.
, and
Zhang
,
T.
, 2019
, “
A Novel Control Scheme for Aircraft Engine Based on Sliding Mode Control With Acceleration/Deceleration Limiter
,” IEEE Access
,
7
, pp. 3572
–3580
.10.1109/ACCESS.2018.28850196.
Eslami
,
M.
, and
Banazadeh
,
A.
, 2021
, “
Control Performance Enhancement of Gas Turbines in the Minimum Command Selection Strategy
,” ISA Trans.
,
112
, pp. 186
–198
.10.1016/j.isatra.2020.12.0037.
Liu
,
X.
,
Shi
,
J.
,
Qi
,
Y.
, and
Yuan
,
Y.
, 2014
, “
Design for Aircraft Engine Multi-Objective Controllers With Switching Characteristics
,” Chin. J. Aeronaut.
,
27
(5
), pp. 1097
–1110
.10.1016/j.cja.2014.08.0028.
Qin
,
J.
,
Pan
,
M.
,
Xu
,
W.
, and
Huang
,
J.
, 2019
, “
An Output-Based Limit Protection Strategy for Turbofan Engine Propulsion Control With Output Constraints
,” Energies
,
12
(21
), p. 4043
.10.3390/en122140439.
Imani
,
A.
, and
Montazeri-Gh
,
M.
, 2019
, “
A Min-Max Selector Controller for Turbofan Engines With Improvement of Limit Management and Low Computational Burden
,” Trans. Inst. Meas. Control
,
41
(1
), pp. 36
–44
.10.1177/014233121775204310.
Liu
,
X.
, and
Zhao
,
L.
, 2012
, “
Approximate Nonlinear Modeling of Aircraft Engine Surge Margin Based on Equilibrium Manifold Expansion
,” Chin. J. Aeronaut.
,
25
(5
), pp. 663
–674
.10.1016/S1000-9361(11)60432-911.
Petkovic
,
D.
,
Banjac
,
M.
,
Milic
,
S.
,
Petrovic
,
M. V.
, and
Wiedermann
,
A.
, 2020
, “
Modeling the Transient Behavior of Gas Turbines
,” ASME J. Turbomach.
,
142
(8
), p. 081005
.10.1115/1.404645112.
Asgari
,
H.
,
Venturini
,
M.
,
Chen
,
X. Q.
, and
Sainudiin
,
R.
, 2014
, “
Modeling and Simulation of the Transient Behavior of an Industrial Power Plant Gas Turbine
,” ASME J. Eng. Gas Turbines Power
,
136
(6
), p. 061601
.10.1115/1.402621513.
Rodríguez-Molina
,
A.
,
Mezura-Montes
,
E.
,
Villarreal-Cervantes
,
M. G.
, and
Aldape-Pérez
,
M.
, 2020
, “
Multi-Objective Meta-Heuristic Optimization in Intelligent Control: A Survey on the Controller Tuning Problem
,” Appl. Soft Comput.
,
93
, p. 106342
.10.1016/j.asoc.2020.10634214.
Mohammadi
,
E.
,
Montazeri-Gh
,
M.
, and
Khalaf
,
P.
, 2014
, “
Metaheuristic Design and Optimization of Fuzzy-Based Gas Turbine Engine Fuel Controller Using Hybrid Invasive Weed Optimization/Particle Swarm Optimization Algorithm
,” ASME J. Eng. Gas Turbines Power
,
136
(3
), p. 031601
.10.1115/1.402588415.
Tajalli
,
S. M.
, and
Tajalli
,
A.
, 2019
, “
Thermodynamic Simulation of Two-Shaft Gas Turbine to Study Invasive Weeds Optimization and Min-Max Controller Strategies Considering Air-Cooled Blades
,” J. Mech. Sci. Technol.
,
33
(2
), pp. 931
–938
.10.1007/s12206-019-0150-316.
Jafari
,
S.
, and
Nikolaidis
,
T.
, 2019
, “
Meta-Heuristic Global Optimization Algorithms for Aircraft Engines Modelling and Controller Design; A Review, Research Challenges, and Exploring the Future
,” Prog. Aerosp. Sci.
,
104
, pp. 40
–53
.10.1016/j.paerosci.2018.11.00317.
Tang
,
L.
,
Huang
,
J.
, and
Pan
,
M.
, 2017
, “
Switching LPV Control With Double-Layer LPV Model for Aero-Engines
,” Int. J. Turbo Jet-Engines
,
34
(4
), pp. 313
–320
.10.1515/tjj-2016-001418.
Montazeri-Gh
,
M.
, and
Rasti
,
A.
, 2019
, “
Comparison of Model Predictive Controller and Optimized Min-Max Algorithm for Turbofan Engine Fuel Control
,” J. Mech. Sci. Technol.
,
33
(11
), pp. 5483
–5498
.10.1007/s12206-019-0847-319.
Liu
,
Y.
,
Jafari
,
S.
, and
Nikolaidis
,
T.
, 2021
, “
Advanced Optimization of Gas Turbine Aero-Engine Transient Performance Using Linkage-Learning Genetic Algorithm: Part II, Optimization in Flight Mission and Controller Gains Correlation Development
,” Chin. J. Aeronaut.
,
34
(4
), pp. 568
–588
.10.1016/j.cja.2020.07.03720.
Gilani
,
S. I.-U.-H.
,
Baheta
,
A. T.
, and
Rangkuti
,
C.
, 2009
, “
Study the Effect of Variable Vanes on Performance of Axial Compressor for Single Shaft Gas Turbine Cogeneration Plant
,” 2009 Third International Conference on Energy and Environment (ICEE
), Malacca, Malaysia, Dec. 7–8, pp. 40
–44
.10.1109/ICEENVIRON.2009.539867521.
Hashmi
,
M. B.
,
Lemma
,
T. A.
,
Ahsan
,
S.
, and
Rahman
,
S.
, 2021
, “
Transient Behavior in Variable Geometry Industrial Gas Turbines: A Comprehensive Overview of Pertinent Modeling Techniques
,” Entropy
,
23
(2
), p. 250
.10.3390/e2302025022.
Enalou
,
H. B.
,
Soreshjani
,
E. A.
,
Rashed
,
M.
,
Yeoh
,
S. S.
, and
Bozhko
,
S.
, 2017
, “
A Detailed Modular Governor-Turbine Model for Multiple-Spool Gas Turbine With Scrutiny of Bleeding Effect
,” ASME J. Eng. Gas Turbines Power
,
139
(11
), p. 114501
.10.1115/1.403694723.
Mehrpanahi
,
A.
,
Payganeh
,
G.
,
Arbabtafti
,
M.
, and
Hamidavi
,
A.
, 2017
, “
Semi-Simplified Black-Box Dynamic Modeling of an Industrial Gas Turbine Based on Real Performance Characteristics
,” ASME J. Eng. Gas Turbines Power
,
139
(12
), p. 121601
.10.1115/1.403733624.
Li
,
X.
,
Ying
,
Y. L.
,
Wang
,
Y. Y.
, and
Li
,
J. C.
, 2018
, “
A Component Map Adaptation Method for Compressor Modeling and Diagnosis
,” Adv. Mech. Eng.
,
10
(3
), pp. 1–13.10.1177/168781401876716525.
Li
,
Y. G.
,
Ghafir
,
M. F. A.
,
Wang
,
L.
,
Singh
,
R.
,
Huang
,
K.
,
Feng
,
X.
, and
Zhang
,
W.
, 2012
, “
Improved Multiple Point Nonlinear Genetic Algorithm Based Performance Adaptation Using Least Square Method
,” ASME J. Eng. Gas Turbines Power
,
134
(3
), p. 031701
.10.1115/1.400439526.
Montazeri-Gh
,
M.
, and
Rasti
,
A.
, 2019
, “
Analyzing Different Numerical Linearization Methods for the Dynamic Model of a Turbofan Engine
,” Mech. Ind.
,
20
(3
), p. 303
.10.1051/meca/201901227.
Kulikov
,
G. G.
, and
Thompson
,
H. A.
, 2004
, Dynamic Modelling of Gas Turbines: Identification, Simulation, Condition Monitoring and Optimal Control
,
Springer Science & Business Media
, London, UK.28.
Wang
,
J.
, 2020
, “
Identification-Based Aeroengine Nonlinear Modeling: A Comparative Study
,” Simulation
,
96
(2
), pp. 199
–206
.10.1177/003754971986019329.
Chen
,
Q.
,
Huang
,
J.
,
Pan
,
M.
, and
Lu
,
F.
, 2019
, “
A Novel Real-Time Mechanism Modeling Approach for Turbofan Engine
,” Energies
,
12
(19
), p. 3791
.10.3390/en1219379130.
Yazar
,
I.
,
Kiyak
,
E.
,
Caliskan
,
F.
, and
Hikmet Karakoc
,
T.
, 2018
, “
Simulation-Based Dynamic Model and Speed Controller Design of a Small-Scale Turbojet Engine
,” Aircr. Eng. Aerosp. Technol.
,
90
(2
), pp. 351
–358
.10.1108/AEAT-09-2016-015031.
Zhao
,
H.
,
Liu
,
J. F.
, and
Yu
,
D. R.
, 2011
, “
Approximate Nonlinear Modeling and Feedback Linearization Control for Aeroengines
,” ASME J. Eng. Gas Turbines Power
,
133
(11
), p. 111601
.10.1115/1.400364232.
Zhu
,
L.
,
Liu
,
J.
,
Ma
,
Y.
,
Zhou
,
W.
, and
Yu
,
D.
, 2020
, “
A Corrected Equilibrium Manifold Expansion Model for Gas Turbine System Simulation and Control
,” Energies
,
13
(18
), p. 4904
.10.3390/en1318490433.
Wang
,
X.
,
Zhao
,
J.
, and
Sun
,
X.-M.
, 2016
, “
Overshoot-Free Acceleration of Aero-Engines: An Energy-Based Switching Control Method
,” Control Eng. Pract.
,
47
, pp. 28
–36
.10.1016/j.conengprac.2015.12.00734.
Shi
,
Y.
,
Zhao
,
J.
, and
Liu
,
Y.
, 2017
, “
Switching Control for Aero-Engines Based on Switched Equilibrium Manifold Expansion Model
,” IEEE Trans. Ind. Electron.
,
64
(4
), pp. 3156
–3165
.10.1109/TIE.2016.263347035.
Yan
,
S.
, and
Jun
,
Z.
, 2018
, “
A Safety Protection Control Method for Aero-Engines Based on the Switched Equilibrium Manifold Expansion Model
,” 2018 37th Chinese Control Conference
, Wuhan, China, July 25–27, pp. 2005
–2010
.10.23919/ChiCC.2018.848382036.
Chen
,
C.
, and
Zhao
,
J.
, 2018
, “
A Nonlinear Switching Control Strategy of Regulation and Safety Protection for Aero-Engines Based on the Equilibrium Manifold Expansion Model
,” Proc. Inst. Mech. Eng., Part I
,
232
(4
), pp. 355
–368
.10.1177/095965181770940737.
Chen
,
C.
,
Ma
,
D.
,
Mao
,
X.
, and
Sun
,
H.
, 2020
, “
Acceleration Control Design for Turbofan Aero-Engines Based on a Switching Control Strategy
,” Proceedings of the 32nd 2020 Chinese Control and Decision Conference
, Hefei, China, Aug. 22–24, pp. 7
–12
.10.1109/CCDC49329.2020.916449438.
Li
,
S. Y.
,
Li
,
Z. L.
, and
Li
,
S. Y.
, 2020
, “
Improved Method for Gas-Turbine Off-Design Performance Adaptation Based on Field Data
,” ASME J. Eng. Gas Turbines Power
,
142
(4
), p. 041001
.10.1115/1.404447039.
Zhu
,
W.
,
Ren
,
X. D.
,
Li
,
X. S.
,
Gu
,
C. W.
,
Liu
,
Z. T.
,
Yan
,
Z. Y.
,
Zhu
,
H. F.
, and
Zhang
,
T.
, 2021
, “
Improvement of Part-Load Performance of Gas Turbine by Adjusting Compressor Inlet Air Temperature and IGV Opening
,” Front. Energy
, epub.10.1007/s11708-021-0746-z40.
Liu
,
X.
, and
An
,
S.
, 2016
, “
Smooth Switching Controller Design for Multiobjective Control Systems and Applications
,” J. Aerosp. Eng.
,
29
(4
), p. 04016004
.10.1061/(ASCE)AS.1943-5525.000059641.
May
,
R. D.
, and
Garg
,
S.
, 2012
, “
Reducing Conservatism in Aircraft Engine Response Using Conditionally Active Min-Max Limit Regulators
,” ASME
Paper No. GT2012-70017.10.1115/GT2012-7001742.
Montazeri-Gh
,
M.
,
Jafari
,
S.
, and
Ilkhani
,
M. R.
, 2012
, “
Application of Particle Swarm Optimization in Gas Turbine Engine Fuel Controller Gain Tuning
,” Eng. Optim.
,
44
(2
), pp. 225
–240
.10.1080/0305215X.2011.576760Copyright © 2022 by ASME
You do not currently have access to this content.
