The use of concentrated solar radiation as the source of process heat to drive biomass gasification offers potential increases in yield and efficiency over conventional approaches to gasification but requires that temporal variations in output be alleviated with thermal storage or hybridization. The impacts of thermal storage and degree of hybridization on the efficiency, specific yield, and variation in output of a solar gasification facility are explored through parametric simulations of a generalized 100 MWth solar receiver facility. Nominal syngas yield rates from 1.5 to 50 tonnes/h are considered along with molten carbonate salt storage volumes from 200 to 6500 m3. High solar fractions (95%) result in a maximum thermal efficiency of 79% and specific syngas yield of 139 GJ/ha while low solar fractions (10%) for highly hybridized facilities reduce the thermal efficiency to 72% and specific yield to 88 GJ/ha, akin to conventional gasification processes. Solar fractions greater than 95% result in large variation in synthesis gas yield rate, varying as much as 30:1 throughout the year. This variation can be reduced to below a 4:1 ratio, more acceptable for downstream processes, through either hybridization to achieve solar fractions less than 50% with little to no thermal storage, or alternately the use of 5600 m3 of molten carbonate salt to allow for solar fractions up to 87%.
Issue Section:
Research Papers
References
1.
U.S. Energy Information Administration (EIA)
2012
, “Annual Energy Outlook 2012
,” DOE/EIA-0383(2012), Washington DC.2.
Tilman
, D.
, Hill
, J.
, and Lehman
, C.
, 2006
, “Carbon-Negative Biofuels From Low-Input High-Diversity Grassland Biomass
,” Science
, 314
(5805
), pp. 1598
–1600
.10.1126/science.11333063.
Cheng
, J.
, 2010
, Biomass to Renewable Energy Processes
, CRC Press
, Boca Raton, FL
, pp. 437
–489
.4.
Steinfeld
, A.
, and Meier
, A.
, 2004
, Encyclopedia of Energy
, Elsevier
, New York
, pp. 623
–637
.5.
Gregg
, D. W.
, Taylor
, R. W.
, and Campbell
, J. H.
, 1980
, “Solar Gasification of Coal, Activated Carbon, Coke and Coal and Biomass Mixture
,” Sol. Energy
, 25
(4
), pp. 353
–364
.10.1016/0038-092X(80)90347-36.
Taylor
, R. W.
, Berjoan
, R.
, and Coutures
, J.
, 1983
, “Solar Gasification of Carbonaceous Materials
,” Sol. Energy
, 30
(6
), pp. 513
–525
.10.1016/0038-092X(83)90063-47.
Murray
, J. P.
, and Fletcher
, E. A.
, 1994
, “Reaction of Steam With Cellulose in a Fluidized Bed Using Concentrated Sunlight
,” Energy
, 19
(10
), pp. 1083
–1098
.10.1016/0360-5442(94)90097-38.
Flechsenhar
, M.
, and Sasse
, C.
, 1995
, “Solar Gasification of Biomass Using Oil Shale and Coal as Candidate Materials
,” Energy
, 20
(8
), pp. 803
–810
.10.1016/0360-5442(95)00023-A9.
Tamaura
, Y.
, Tsuji
, M.
, and Yoshida
, S.
, 1999
, “Solar Gasification of Coal Using Carbonate Molten Salt Reactor
,” J. Phys. IV
, 9
(3
), pp. 373
–378
.10.1051/jp4:199935810.
Matsunami
, J.
, Yoshida
, S.
, and Oku
, Y.
, 2000
, “Coal Gasification by CO2 Gas Bubbling in Molten Salt for Solar/Fossil Energy Hybridization
,” Sol. Energy
, 68
(3
), pp. 257
–261
.10.1016/S0038-092X(99)00074-211.
Kodama
, T.
, Kondoh
, Y.
, and Tamagawa
, T.
, 2002
, “Fluidized Bed Coal Gasification With CO2 Under Direct Irradiation With Concentrated Visible Light
,” Energy Fuels
, 16
(5
), pp. 1264
–1270
.10.1021/ef020053x12.
Adinberg
, R.
, Epstein
, M.
, and Karni
, J.
, 2004
, “Solar Gasification of Biomass: A Molten Salt Pyrolysis Study
,” ASME J. Sol. Energy Eng.
, 126
(3
), pp. 850
–857
.10.1115/1.175357713.
Trommer
, D.
, Noembrini
, F.
, and Fasciana
, M.
, 2005
, “Hydrogen Production by Steam-Gasification of Petroleum Coke Using Concentrated Solar Power—I. Thermodynamic and Kinetic Analyses
,” Int. J. Hydrogen Energy
, 30
(6
), pp. 605
–618
.10.1016/j.ijhydene.2004.06.00214.
Z'Graggen
, A.
, Haueter
, P.
, and Trommer
, D.
, 2006
, “Hydrogen Production by Steam-Gasification of Petroleum Coke Using Concentrated Solar Power—II Reactor Design, Testing, and Modeling
,” Int. J. Hydrogen Energy
, 31
(6
), pp. 797
–811
.10.1016/j.ijhydene.2005.06.01115.
Perkins
, C. M.
, Woodruff
, B.
, and Andrews
, L.
, 2008
, “Synthesis Gas Production by Rapid Solar Thermal Gasification of Corn Stover
,” 14th Biennial CSP SolarPACES, Las Vegas, NV, March 4–7, pp. 1
–8
.16.
Piatkowski
, N.
, and Steinfeld
, A.
, 2008
, “Solar-Driven Coal Gasification in a Thermally Irradiated Packed-Bed Reactor
,” Energy Fuels
, 22
(3
), pp. 2043
–2052
.10.1021/ef800027c17.
Piatkowski
, N.
, Wieckert
, C.
, and Steinfeld
, A.
, 2009
, “Experimental Investigation of a Packed-Bed Solar Reactor for the Steam-Gasification of Carbonaceous Feedstocks
,” Fuel Process. Technol.
, 90
(3
), pp. 360
–366
.10.1016/j.fuproc.2008.10.00718.
Melchior
, T.
, Perkins
, C.
, and Lichty
, P.
, 2009
, “Solar-Driven Biochar Gasification in a Particle-Flow Reactor
,” Chem. Eng. Process.
, 48
(8
), pp. 1279
–1287
.10.1016/j.cep.2009.05.00619.
Lichty
, P.
, Perkins
, C.
, and Woodruff
, B.
, 2010
, “Rapid High Temperature Solar Thermal Biomass Gasification in a Prototype Cavity Reactor
,” ASME J. Sol. Energy Eng.
, 132
(1
), p. 011012
.10.1115/1.400035620.
Kodama
, T.
, Gokon
, N.
, and Enomoto
, S.
, 2010
, “Coal Coke Gasification in a Windowed Solar Chemical Reactor for Beam-Down Optics
,” ASME J. Sol. Energy Eng.
, 132
(4
), p. 041004
.10.1115/1.400208121.
Gokon
, N.
, Ono
, R.
, and Hatamachi
, T.
, 2012
, “CO2 Gasification of Coal Cokes Using Internally Circulating Fluidized Bed Reactor by Concentrated Xe-Light Irradiation for Solar Gasification
,” Int. J. Hydrogen Energy
, 37
(17
), pp. 12128
–12137
.10.1016/j.ijhydene.2012.05.13322.
Kribus
, A.
, Zaibel
, R.
, and Carey
, D.
, 1998
, “A Solar-Driven Combined Cycle Power Plant
,” Sol. Energy
, 62
(2
), pp. 121
–129
.10.1016/S0038-092X(97)00107-223.
Sudiro
, M.
, and Bertucco
, A.
, 2007
, “Synthetic Fuels by a Limited CO2 Emission Process Which Uses Both Fossil and Solar Energy
,” Energy Fuels
, 21
(6
), pp. 3668
–3675
.10.1021/ef700325524.
Kaniyal
, A. A.
, van Eyk
, P. J.
, and Nathan
, G. J.
, 2013
, “Polygeneration of Liquid Fuels and Electricity by the Atmospheric Pressure Hybrid Solar Gasification of Coal
,” Energy Fuels
, 27
(6
), pp. 3538
–3555
.10.1021/ef400198v25.
Kaniyal
, A. A.
, van Eyk
, P. J.
, and Nathan
, G. J.
, 2013
, “Dynamic Modelling of the Co-Production of Liquid Fuels and Electricity From a Hybrid Solar Gasifier With Various Fuel Blends
,” Energy Fuels
, 27
(6
), pp. 3556
–3569
.10.1021/ef400217n26.
Sheu
, E. J.
, Mitsos
, A.
, and Eter
, A. A.
, 2012
, “A Review of Hybrid Solar—Fossil Fuel Power Generation Systems and Performance Metrics
,” ASME J. Sol. Energy Eng.
, 134
(4
), p. 041006
.10.1115/1.400697327.
Hathaway
, B. J.
, Davidson
, J. H.
, and Kittelson
, D. B.
, 2011
, “Solar Gasification of Biomass: Kinetics of Pyrolysis and Steam Gasification in Molten Salt
,” J. Sol. Energy Eng.
, 133
(2
), p. 021011
.10.1115/1.400368028.
Hathaway
, B. J.
, Honda
, M.
, and Kittelson
, D. B.
, 2012
, “Steam Gasification of Plant Biomass Using Molten Carbonate Salts
,” Energy
, 49
(1
), pp. 211
–217
.10.1016/j.energy.2012.11.00629.
Zvegilsky
, D.
, Adinberg
, R.
, and Epstein
, M.
, 2012
, “Pyrolysis and Gasification of Rice Husks and the Solar Option
,” Proceedings of the 2012 Solar Power and Chemical Energy Systems Conference
(SolarPACES 2012), Marrakech, Morocco, September 11–14.30.
Hathaway
, B. J.
, Lipiński
, W.
, and Davidson
, J. H.
, 2012
, “Heat Transfer in a Solar Cavity Receiver: Design Considerations
,” Numer. Heat Transfer, Part A
, 62
(5
), pp. 445
–461
.10.1080/10407782.2012.70347131.
Coyle
, R. T.
, Thomas
, T. M.
, and Schissel
, P.
, 1985
, “The Corrosion of Materials in Molten Alkali Carbonate Salt at 900 °C
,” Solar Energy Research Institute, Golden, CO, Paper No. SRI/TR-255-2553.32.
Kohl
, A. L.
, Harty
, R. B.
, and Johanson
, J. G.
, 1978
, “Molten Salt Coal Gasification Process
,” Chem. Eng. Prog.
, 74
(8
), pp. 73
–79
.33.
Ben-Zvi
, R.
, Epstein
, M.
, and Segal
, A.
, 2011
, “Coupling Solar Tower System and Molten Salt Storage for the Generation of Electricity Using the Beam-Down Optics
,” 2011 Solar Power and Chemical Energy Systems Conference (SolarPACES 2011), Granada, Spain, September 20–23
.34.
Martinek
, J.
, Channel
, M.
, and Lewandowski
, A.
, 2010
, “Considerations for the Design of Solar-Thermal Chemical Processes
,” ASME J. Sol. Energy Eng.
, 132
(3
), p. 031013.10.1115/1.400147435.
George
, R.
, and Maxwell
, E.
, 1999
, “High-Resolution Maps of Solar Collector Performance Using a Climatological Solar Radiation Model
,” ASES Annual Conference (Solar 99), Portland, ME, June 12–16
, B. W. R.
Campbell-Howe
, ed., American Solar Energy Society
, Boulder, CO
, pp. 243
–248
.36.
Milbrandt
, A.
, 2005
, “A Geographic Perspective on the Current Biomass Resource Availability in the United States
,” National Renewable Energy Laboratory, Golden, CO, Report No. NREL/TP-560-39181.37.
Wilcox
, S.
, and Marion
, W.
, 2008
, “Users Manual for TMY3 Data Sets
,” National Renewable Energy Laboratory, Golden, CO, Report No. NREL/TP-581-43156.38.
Siegel
, N. P.
, Miller
, J. E.
, and Ermanoski
, I.
, 2013
, “Factors Affecting the Efficiency of Solar Driven Metal Oxide Thermochemical Cycles
,” Ind. Eng. Chem. Res.
, 52
(9
), pp. 3276
–3286
.10.1021/ie400193q39.
Walsh
, P. P.
, and Fletcher
, P.
, 2004
, Gas Turbine Performance
, Blackwell Science, Limited
, Malden, MA
.40.
Berdahl
, P.
, and Martin
, M.
, 1984
, “Emissivity of Clear Skies
,” Sol. Energy
, 32
(5
), pp. 663
–664
.10.1016/0038-092X(84)90144-041.
Churchill
, S. W.
, and Chu
, H. H.
, 1975
, “Correlating Equations for Laminar and Turbulent Free Convection From a Vertical Plate
,” Int. J. Heat Mass Transfer
, 18
(11
), pp. 1323
–1329
.10.1016/0017-9310(75)90243-442.
McAdams
, W. H.
, 1954
, Heat Transmission
, McGraw-Hill
, New York
, p. 321
.43.
Churchill
, S.
, and Bernstein
, M.
, 1977
, “A Correlating Equation for Forced Convection From Gases and Liquids to a Circular Cylinder in Crossflow
,” ASME J. Heat Transfer
, 99
(2
), pp. 300
–306
.10.1115/1.345068544.
Ladwing
, M.
, and Stevens
, M.
, 2011
, “KA26 Combined Cycle Power Plant as Ideal Solution to Balance Load Fluctuations
,” Power Plant Technology Forum, Hannover, Germany, April 5–8.Copyright © 2014 by ASME
You do not currently have access to this content.
